1-800-663-4209 | Your feedback matters, take a quick survey Website Feedback
PV14-Series
200:1, NEMA 4 (IP66), Electronic Proportioning Valves
Models In Stock
- Programmable Direct or Reverse Acting Control
- Precision Control Is Achieved Via a 10-Bit Converter Controlling a 200 Step Per Revolution Motor
- Rugged Construction for Industrial Applications
- External Safety Override Contacts to Open/Close Valve
PV14-Series
From
$
1,633.08
Models In Stock
Product Overview
- Actuator Type DC step motor
- Adjustments None
- Cable Length 16 in
- Cable Type Pigtail
- Electrical Connection 1/2 in NPT
- Enclosure Material Epoxy Painted Aluminum
- Enclosure Ratings IP66, NEMA Type 4X
- Flow Rate Note Maximum Flow @ 50 psi
- Input Control Signal 4 to 20 mA, 1 to 5 Vdc
- Input Control Signal Note 4 to 20 mA control signal (250 Ω impedance) and dual external switch contact sensing via 5 Vdc signal
- Operating Temperature, Max 49 °C
- Operating Temperature, Min 0 °C
- Process Connection Type NPT Female
- Process Temperature, Max 121 °C
- Process Temperature, Min -18 °C
- Supply Power Note 12 to 24 Vdc @ 5 A (10 W typical, 23 W maximum)(2.5 A for 3⁄4" valve, 38 W maximum)
- Supply Voltage 12 to 24 Vdc
- Valve Type In-Line Globe
- Wire Gauge 22 AWG
An electronically controlled proportioning valve (ECV) will take an electrical input signal (usually 4 to 20 mA) and proportion the amount of flow through a pipe from fully closed to fully open. These valves are used in industrial automation controls as proportional actuators and other industrial control applications. The OmegaTM ECV valve features programmable reverse or direct acting control. Direct acting means that, as the current signal rises, the valve allows more flow, while reverse acting will decrease the flow rate with an increasing current signal. These units can also be programmed to sense a failure in the current loop and fully close/ open the valve upon the signal level’s dropping below 4.0 mA. Dry contact remote switches can be used in conjunction with the standard current signal to provide an alarm signal which fully closes/opens the valve. The rugged epoxy-coated aluminum package insures NEMA-4X protection or the powerful microprocessor and servo actuator.
SPECIFICATIONS
ELECTRONICS:
Power Supply: 12-16 Vdc @1.5 A (10 Watts typ, 23 Watts max) (2.5 Amps for ¾ valve, 38 Watts max)
Inputs: 4 to 20 mA control signal (250 ? impedance), and dual external switch contact sensing via 5 Vdc signal
Control Modes: direct or reverse, full or split range, high or low range, fail condition open or closed
Adjustments: None
Operating Temp.: 0 to 49°C (32 to 120°F)
Enclosure: NEMA-4X, epoxy painted aluminum
Connections: ½ NPT conduit (16" 22 AWG pigtail leads)
ACTUATOR:
Type: DC step motor, 200 steps/rev, 4 rev travel Resolution: 200:1 (0.5%) (4 steps increment)
Speed: 18 rpm
Torque: 57.5 in-oz (188 in-oz ¾ valve)
VALVE:
Type: In-line globe
Temp.: -18 to 120°C (0 to 250°F)
Pressure: 120 psi max (70 psi on ¾ "valve)
Max Flow: GPM= Cv (DP/SG) ½ liquids; for gases use standard equation found in solenoid valve section
Wetted Parts: Ethylene propylene rubber O-ring, PTFE washer, and valve body. (Brass models have 303 SS internal trim.)
COMPLETE UNIT:
Dimensions: 216 H x 185 W x 137 mm D (8.5 x 7.3 x 5.4");
½ valve: 229 H x 185 W x 137 mm D (9 x 7.3 x 5.4");
¾ valve: 305 H x 203 W x 191 mm D (12 x 8 x 7.5")
Weight: 3.2 kg (7 lbs);
½ valve: 4.5 kg (10 lb);
¾ valve: 8.2 kg (18 lb)
U12Y100
Specifications:
Power Supply: 120 Vac or 240 Vac
Output: 12 Vdc unregulated @ 3 A Connections: 2.1 m (7') power cord, 3-pin DIN connector with 1.8 m (6') of 3-conductor 22 AWG, pigtail leads
Dimensions: 102 W x 152 L x 76 mm H (4 x 6 x 3")
Weight: 1.4 kg (3 lb)
SPECIFICATIONS
ELECTRONICS:
Power Supply: 12-16 Vdc @1.5 A (10 Watts typ, 23 Watts max) (2.5 Amps for ¾ valve, 38 Watts max)
Inputs: 4 to 20 mA control signal (250 ? impedance), and dual external switch contact sensing via 5 Vdc signal
Control Modes: direct or reverse, full or split range, high or low range, fail condition open or closed
Adjustments: None
Operating Temp.: 0 to 49°C (32 to 120°F)
Enclosure: NEMA-4X, epoxy painted aluminum
Connections: ½ NPT conduit (16" 22 AWG pigtail leads)
ACTUATOR:
Type: DC step motor, 200 steps/rev, 4 rev travel Resolution: 200:1 (0.5%) (4 steps increment)
Speed: 18 rpm
Torque: 57.5 in-oz (188 in-oz ¾ valve)
VALVE:
Type: In-line globe
Temp.: -18 to 120°C (0 to 250°F)
Pressure: 120 psi max (70 psi on ¾ "valve)
Max Flow: GPM= Cv (DP/SG) ½ liquids; for gases use standard equation found in solenoid valve section
Wetted Parts: Ethylene propylene rubber O-ring, PTFE washer, and valve body. (Brass models have 303 SS internal trim.)
COMPLETE UNIT:
Dimensions: 216 H x 185 W x 137 mm D (8.5 x 7.3 x 5.4");
½ valve: 229 H x 185 W x 137 mm D (9 x 7.3 x 5.4");
¾ valve: 305 H x 203 W x 191 mm D (12 x 8 x 7.5")
Weight: 3.2 kg (7 lbs);
½ valve: 4.5 kg (10 lb);
¾ valve: 8.2 kg (18 lb)
U12Y100
Specifications:
Power Supply: 120 Vac or 240 Vac
Output: 12 Vdc unregulated @ 3 A Connections: 2.1 m (7') power cord, 3-pin DIN connector with 1.8 m (6') of 3-conductor 22 AWG, pigtail leads
Dimensions: 102 W x 152 L x 76 mm H (4 x 6 x 3")
Weight: 1.4 kg (3 lb)
Accessories
Unregulated power supply, 12 Vdc @ 3 Amps
$213.41
0 In Stock
Show Ratings & Reviews
Rated 5 out of
5
by
Swin Housing LLC from
speedy delivery/ good quality
Omega was very quick to deliver the part that I was looking for!
Date published: 2022-11-07
What power supply and controller are recommended? The part numbers in the .pdf data sheet are no longer valid part numbers for Omega.
Power supply needs to 12VDC with a minimum of 3A current rating. Unfortunately we no longer have a source for this supply
Date published: 2024-01-23
What is the maximum allowable and/or failure pressure for this valve?
Thank you for your inquiry, the maximum Pressure is 120 psi (70 psi on 3 ⁄4" valve)
Date published: 2022-10-26
Are there any CAD models that can be posted for fitting this part with assemblies?
Thank you for your inquire
Omega at this time doesn't have any CAD drawings that are available for this part.
Date published: 2023-02-28
How seconds does this valve takes from fully open to fully close (reacting time)
Hello, thank you for reaching out to Omega Engineering. We are checking the response time with the engineering team. Can you kindly send us an email at pressure@omega.com ? we will email you the response time once we have it.
Date published: 2023-07-31